Rheem 50 Manuel de service Page 1

This water heater must be installed and serviced by a qualified person. Please leave this guide with a responsible officer. Owner’s Guide and Insta

WATER SUPPLIES 10 ANODE INSPECTION AND REPLACEMENT The anode installed in your water heater will slowly dissipate whilst protecting the cylinder. The

WATER SUPPLIES 11 +0.4 +0.80very corrosive very scalingscalingcorrosive-1.0no warranty applies to a:temperature pressure relief valve or awater heate

12 SAVE A SERVICE CALL Check the items below before making a service call. You will be charged for attending to any condition or fault that is not r

SAVE A SERVICE CALL 13 TEMPERATURE PRESSURE RELIEF VALVE RUNNING Normal Operation It is normal and desirable that this valve allows a small quantity

14 INSTALLATION THIS WATER HEATER IS NOT SUITABLE FOR POOL HEATING INSTALLATION STANDARDS The water heater must be installed: by a qualified pers

INSTALLATION 15 SAFE TRAY Where damage to property can occur in the event of the water heater leaking, the water heater must be inst

INSTALLATION 16 CIRCULATED HOT WATER FLOW AND RETURN SYSTEM If a Rheem water heater is to be installed as part of a circulated hot water flow and retu

INSTALLATION 17 REDUCING HEAT LOSSES The cold water line to and the hot water line from the water heater must be insulated in accordance with the requ

INSTALLATION 18 DIMENSIONS AND TECHNICAL DATA Model 613 050 613 315 616 315 Heating Units No. 3 3 6 Hot Water Delivery litres 50 315 315 Thermost

INSTALLATION 19 TYPICAL INSTALLATION – OUTDOOR LOCATION OUTDOOR LOCATIONSINDOOR LOCATIONS TYPICAL INSTALLATION – INDOOR LOCATION OUTDOOR LOCATIONSI

PATENTS This water heater may be protected by one or more patents or registered designs. TRADEMARKS ® Registered trademark of Rheem Australia Pty Lt

20 CONNECTIONS – PLUMBING All plumbing work must be carried out by a qualified person and in accordance with the Standard AS/NZS 350

CONNECTIONS – PLUMBING 21 EXPANSION CONTROL VALVE Local regulations may make it mandatory to install an expansion control valve (ECV) in the cold wate

22 CONNECTIONS – ELECTRICAL The power supply to the water heater must not be switched on until the water heater is filled with water and a satisfact

CONNECTIONS – ELECTRICAL 23 WIRING DIAGRAMS Electrical Circuit for 613 Models – Robertshaw “ST” Thermostats Electrical Circuit for 616 Models –

24 MULTIPLE INSTALLATIONS A multiple installation of Rheem water heaters on a single manifold or multiple manifolds is possible, using the Rheem E

MULTIPLE INSTALLATIONS 25 Single Bank of Water Heaters Multiple Banks of Water Heaters TPR Valve Drain Line Common Disch

MULTIPLE INSTALLATIONS 26 TYPICAL INSTALLATION – RHEEM HEAVY DUTY ELECTRIC WATER HEATERS RHEEM COMMERCIAL WATER HEATERS TYPICAL INSTALLAT

MULTIPLE INSTALLATIONS 27 MANIFOLD ARRANGEMENT Hot Manifold Assembly Cold Manifold Assembly

28 COMMISSIONING TO FILL AND TURN ON THE WATER HEATER The power supply to the water heater must not be switched on until the water heater is filled

29 DRAINING THE WATER HEATER Warning: Exercise care, as water discharged from the water heater may be of a very high temperature. To drain the wat

3 CONTENTS RESPONSIBLE OFFICER – We recommend you read pages 4 to 13. The other pages are intended for the installer but may be of interest. Abou

30 This page is intentionally blank.

31 RHEEM HEAVY DUTY ELECTRIC MAINS PRESSURE WATER HEATER WARRANTY - AUSTRALIA ONLY ELECTRIC WATER HEATER MODELS 613050, 613315, 616315 1. THE RHEEM

RHEEM HEAVY DUTY ELECTRIC MAINS PRESSURE WATER HEATER WARRANTY - AUSTRALIA ONLY Revision Date: 2013 April 122048P 32 ELECTRIC WATER HEATER MODELS 61

4 ABOUT YOUR WATER HEATER WATER HEATER APPLICATION This water heater is designed for the purpose of heating potable water. Its use in an application

ABOUT YOUR WATER HEATER 5 THERMOSTATS The thermostats automatically control the electricity supply to the heating units so a constant temperature is m

ABOUT YOUR WATER HEATER 6 TO TURN OFF THE WATER HEATER If it is necessary to turn off the water heater: Switch off the electrical supply at the isol

7 REGULAR CARE MINOR SIX MONTH MAINTENANCE It is recommended minor maintenance be performed every six months by a responsible officer. The minor ma

REGULAR CARE 8 TEMPERATURE PRESSURE RELIEF VALVE This valve is near the top of the water heater and is essential for its safe operation. It is poss

9 WATER SUPPLIES This water heater must be installed in accordance with this advice to be covered by the Rheem warranty. This wate